Categories
Uncategorized

How to convert 3sfe from distributor to coil packs for Toyota (its possible!)

 

I accidentally blew up my mum’s car when passing a truck on a passing lane the car was a 1997 Toyota ipsum with a 3sfe engine the engine gave no warning as i gunned it pass a truck and it spat a rod out the block with two big holes on each side of the block on investigation the con rod had separated  from the piston i was lucky i had spare oil in the car as i drove it and extra 5 miles just topping it up with oil to get to my destination.I got a tow company to dropped it back to my house the next day .A decision was made to purchase a new engine for the car i opened the hood and i looked at the engine and i noticed it had a distributor on it so i ordered a second hand replacement engine from the wreckers for $400 nzd. I picked up the engine and got it back to home . The next day i opened up the bonnet and discovered my eyes had tricked me and the engine had coil packs on it . I searched the web to see if it was possible to convert a 3sfe with a distributor and change it over to coils packs but could not find much info on it so i have decided to show you how i did the conversion .

 

YOU TUBE VIDEO

OIL PUMP HOUSINGS NEEDED TO BE SWAPPED
I needed to remove the oil pump housing and swap them over the cam shaft pulley just slides off and you will need to swap that pulley cog. The crank angle sensor is not on the engine with the distributor.

 

The parts that are different.
I have made a diagram of the differences in the parts. the only way i found to remove the crank angle sensor was to slide off the cam shaft drive pulley i also swapped the oil pump from the engine from replacement engine to the housing that required the crank angle sensor .
dissy removed from replacement engine
I had to remove the distributor from the replacement engine . It was held in place by the cap and the end of the distributor just fitted in the back of the cam shaft.
The distributor
The removed Distributor.
THE CAP OFF THE NON DISTRIBUTOR ENGINE
This was were distributor  went on the engine that had coils this had to be installed were the distributor came out of for the replacement engine i made sure i put heaps a sealant on it .
Sealant applied to the sealing cap                                                                                                                                                                                                                                                                                   SETTING UP THE CAM TIMING

 

step 1( Do not force crank shaft around to prevent bent valves ) The blue arrow is a marking on the oil pump housing . Between the 2 red arrows is a tiny line stamped on the cam shaft drive sprocket on crank you must line these up and position the cam shaft sprocket on cylinder head in next photo

 

STEP 2 This is the cylinder head cam sprocket all you have to do here is look at the top of the sprocket and you will see a small hole and there is a line behind. line it up and line up step 1 together put the cam belt on .The direction  of engine is in photo below and the timing will be set do 2 revolutions to make sure nothing is hitting as far as i no this is a non interference engine but be safe in this step.
Engine direction. Top cam shaft sprocket turning clockwise.
The cam belt should be assembled in this order.
There is a stud and it needs to be removed from old engine over to replacement engine it holds the coil pack to the cylinder head.

 

THE NASTY BIG HOLE IN BLOCK HOLE ON EACH SIDE.
PHOTO OF ME WRITER FOR INFO.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

151 replies on “How to convert 3sfe from distributor to coil packs for Toyota (its possible!)”

Long time supporter, and thought I’d drop a comment.

Your wordpress site is very sleek – hope you don’t mind me asking what theme you’re using?
(and don’t mind if I steal it? :P)

I just launched my site –also built in wordpress like yours– but the theme slows (!) the site down quite a bit.

In case you have a minute, you can find it by searching for “royal cbd” on Google (would appreciate
any feedback) – it’s still in the works.

Keep up the good work– and hope you all take care of yourself during the coronavirus scare!

Hi there, I found your website by way of Google even as searching
for a similar topic, your site got here up, it looks great.
I’ve bookmarked it in my google bookmarks.
Hello there, simply became aware of your blog via
Google, and located that it’s really informative.
I’m going to be careful for brussels. I will be grateful in case you proceed this in future.

A lot of other folks might be benefited from your writing.
Cheers!

Also visit my website https://royalcbd.com/

Hi there, just became alert to your blog through Google, and found that it’s really informative. I am going to watch out for brussels. I抣l appreciate if you continue this in future. Many people will be benefited from your writing. Cheers!

Its such as you learn my mind! You seem to grasp so much about this, like you wrote the ebook in it or something. I think that you just can do with some p.c. to power the message home a bit, however instead of that, this is magnificent blog. An excellent read. I’ll certainly be back.

Taxi moto line
128 Rue la Boétie
75008 Paris
+33 6 51 612 712  

Taxi moto paris

Great post. I was checking constantly this blog and I’m impressed!

Very useful information specifically the last part 🙂 I care for such info a lot.

I was seeking this particular info for a very long time.

Thank you and good luck.

Woah! I’m really loving the template/theme of this site. It’s simple, yet effective.
A lot of times it’s hard to get that “perfect balance” between usability and appearance.
I must say you’ve done a very good job with this.
Also, the blog loads very quick for me on Safari.
Exceptional Blog!

my page: sardinia apartment

With havin so much content and articles do you ever run into any issues
of plagorism or copyright infringement? My site has a lot of unique content I’ve either authored myself or outsourced but it seems a
lot of it is popping it up all over the internet without my authorization. Do you know any solutions
to help stop content from being stolen? I’d genuinely appreciate it.

Hi! This post couldn’t be written any better! Reading through
this post reminds me of my previous room mate!
He always kept talking about this. I will forward this article to him.

Pretty sure he will have a good read. Many thanks for sharing!

Do you mind if I quote a couple of your articles
as long as I provide credit and sources back to your site?
My website is in the exact same area of interest as yours and my users would genuinely benefit from a lot of the information you present
here. Please let me know if this alright with you.

Appreciate it!

Pretty great post. I simply stumbled upon your blog and wished to say that
I’ve really enjoyed browsing your blog posts.
After all I’ll be subscribing in your rss feed and I am hoping you write again soon!

You really make it seem so easy with your presentation but I find this topic to be really
something which I think I would never understand. It seems too complicated and extremely broad for me.
I’m looking forward for your next post, I will try to get the hang of it!

Its like you read my mind! You appear to understand a lot
approximately this, like you wrote the guide in it or something.

I feel that you just can do with some % to pressure the message house a bit,
but instead of that, that is fantastic blog.
A fantastic read. I will certainly be back.

Hi! I could have sworn I’ve visited this web site before but
after looking at some of the posts I realized it’s new
to me. Nonetheless, I’m certainly pleased I stumbled upon it and I’ll be book-marking it and checking back regularly!

Wow, great stuff. I have been considering this for a few years. I’m glad to seemingly find someone that comes to the same conclusions as me. At least it seems that’s the case. I’ll keep visiting your site to stay informed.

An fascinating discussion will be worth comment. I do think that you should write on this topic, it might not often be a taboo subject but generally persons are insufficient to talk on such topics. To the next. Cheers

It’s a shame you don’t have a donate button! I’d definitely donate to this
outstanding blog! I suppose for now i’ll settle for bookmarking and adding your RSS feed to my Google account.
I look forward to brand new updates and will talk about
this blog with my Facebook group. Chat soon!

Excellent beat ! I would like to apprentice at the same time as you amend your website,
how could i subscribe for a blog site? The account helped me
a acceptable deal. I had been a little bit familiar of this your broadcast offered shiny transparent idea

When I originally left a comment I seem to have clicked on the -Notify me when new comments are added- checkbox and now every time a
comment is added I recieve 4 emails with the same comment.
There has to be an easy method you can remove me from that service?
Kudos!

This is the right site for anybody who really wants
to find out about this topic. You know so much its almost hard to argue
with you (not that I personally will need to…HaHa).

You certainly put a new spin on a subject which has been discussed for years.

Great stuff, just great!

Feel free to visit my website – private driver

Terrific article! That is the type of information that are supposed to be
shared around the internet. Disgrace on Google for no longer positioning
this submit upper! Come on over and visit my web site . Thanks =)

My web page: porn

hey there and thank you for your information – I’ve
certainly picked up something new from right here.
I did however expertise some technical issues using
this site, since I experienced to reload the website lots of times previous to I could get
it to load correctly. I had been wondering if your hosting
is OK? Not that I am complaining, but slow loading instances times will sometimes affect your placement in google and can damage
your high quality score if ads and marketing with Adwords.
Well I am adding this RSS to my email and can look out for
much more of your respective fascinating content. Make sure you update this again very soon.

I know this if off topic but I’m looking into starting my own blog and was wondering what all is required to get set up?
I’m assuming having a blog like yours would cost a pretty penny?
I’m not very internet smart so I’m not 100%
certain. Any recommendations or advice would be greatly appreciated.
Cheers

After going over a handful of the blog articles on your website, I
honestly like your way of writing a blog. I saved it to my bookmark webpage list
and will be checking back in the near future.

Please check out my web site too and tell me how you feel.

Hello! I know this is kinda off topic but I was wondering which
blog platform are you using for this site?
I’m getting sick and tired of WordPress because I’ve had issues with hackers and I’m looking at options for another platform.

I would be fantastic if you could point me in the direction of a good platform.

Very nice post. I just stumbled upon your blog and wished to say that I have
really enjoyed surfing around your blog posts.
After all I’ll be subscribing to your rss feed and I hope you write
again soon!

Good day! This is my first visit to your blog! We are a team of volunteers and starting a new initiative in a community in the same niche.
Your blog provided us useful information to work on. You have done a outstanding
job!

Hi there superb blog! Does running a blog such as this take a great deal of work?
I have absolutely no expertise in coding but
I had been hoping to start my own blog soon. Anyways, if you have any
ideas or techniques for new blog owners please share.
I know this is off subject nevertheless I simply wanted to ask.
Thanks a lot!

What i do not understood is actually how you are no longer really a lot more neatly-favored than you may
be now. You are so intelligent. You know thus significantly on the
subject of this topic, made me in my view imagine it from so many varied angles.
Its like men and women aren’t interested except it’s something
to do with Girl gaga! Your individual stuffs
great. All the time care for it up!

Please let me know if you’re looking for a author
for your blog. You have some really good articles and I think I would be a good asset.
If you ever want to take some of the load off, I’d love to write some content for
your blog in exchange for a link back to mine. Please send me an email if interested.

Thank you!

I’m extremely impressed with your writing skills as well as with the layout on your weblog.
Is this a paid theme or did you modify it yourself?

Anyway keep up the nice quality writing, it’s rare to see a
great blog like this one these days.

Hey I am so happy I found your website, I really
found you by error, while I was researching on Bing for something else, Anyways
I am here now and would just like to say kudos for
a remarkable post and a all round entertaining blog (I also love the theme/design), I don’t have time
to look over it all at the moment but I have saved it and also included your RSS feeds, so when I
have time I will be back to read much more, Please do keep up the awesome jo.

Hello just wanted to give you a quick heads up and let you know a few of the pictures aren’t loading properly.

I’m not sure why but I think its a linking issue. I’ve tried it
in two different internet browsers and both show the same
results.

Today, I went to the beachfront with my kids. I found a sea shell and gave it to my
4 year old daughter and said “You can hear the ocean if you put this to your ear.”
She put the shell to her ear and screamed.
There was a hermit crab inside and it pinched her ear.
She never wants to go back! LoL I know this is completely off topic but I had to
tell someone!

Its like you read my mind! You appear to know a lot about this,
like you wrote the book in it or something. I think that you can do with some pics to drive the message home a
little bit, but other than that, this is excellent blog.

An excellent read. I’ll definitely be back.

It’s really a cool and useful piece of info. I’m glad
that you shared this helpful info with us. Please keep us up to date like this.
Thanks for sharing.

Take a look at my website … blog [Jenna]

Excellent post. Keep writing such kind of information on your page.
Im really impressed by your blog.
Hi there, You’ve done a great job. I’ll certainly digg it
and individually suggest to my friends. I am confident they will be benefited from this web site.

Also visit my web site; porn

I’m extremely impressed with your writing skills and also with the layout on your
blog. Is this a paid theme or did you customize it yourself?
Anyway keep up the excellent quality writing, it’s rare to see a great blog
like this one today.

Aw, this was a really nice post. Spending some time and actual effort to
make a really good article… but what can I say… I hesitate a lot
and never manage to get nearly anything done.

Excellent article. Keep posting such kind of info on your blog.
Im really impressed by it.
Hey there, You have done an excellent job. I will definitely digg
it and for my part recommend to my friends. I’m confident they will be
benefited from this site.

Have you ever considered writing an e-book or guest authoring
on other blogs? I have a blog based on the same subjects you discuss and would love to have
you share some stories/information. I know my audience would enjoy your
work. If you’re even remotely interested, feel free to send me an e-mail.

Hi! This is kind of off topic but I need some advice from an established blog.
Is it tough to set up your own blog? I’m not very techincal but I can figure things
out pretty fast. I’m thinking about making my own but I’m not sure where to start.
Do you have any points or suggestions? Cheers

Wonderful blog! I found it while surfing around on Yahoo News.

Do you have any suggestions on how to get listed in Yahoo News?
I’ve been trying for a while but I never seem to get there!

Cheers

Have a look at my web site xxx

Thanks a bunch for sharing this with all people you really recognise what you are
speaking approximately! Bookmarked. Please also visit my web site =).
We will have a link exchange contract between us

hey there and thank you for your info – I’ve definitely picked up something new from right here.

I did however expertise a few technical points using this website, since
I experienced to reload the site a lot of times previous
to I could get it to load correctly. I had been wondering if your hosting is
OK? Not that I am complaining, but slow loading instances times will very frequently affect your placement in google
and can damage your quality score if advertising and marketing with Adwords.
Well I’m adding this RSS to my email and can look out
for a lot more of your respective fascinating content.
Ensure that you update this again very soon.

Excellent post. I was checking continuously this blog and I
am impressed! Extremely useful info specially the last part
🙂 I care for such information much. I was looking for
this particular info for a very long time. Thank you and best of luck.

Leave a Reply to istanbul parça eşya taşımacılık Cancel reply

Your email address will not be published. Required fields are marked *